# Service bulletin L09005H$

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

- Type: Service bulletin
- NHTSA id: 10140230
- Published by NHTSA: 2018\-06\-11
- Manufacturer's number: L09005H$
- Manufacturer's date: 2016\-03\-10
- NHTSA component: EXTERIOR LIGHTING

## NHTSA's summary

Headlamp Bulb If the headlamp bulb \(L09005HL\) on a 2016 DS or DJ is being replaced for any reason, engineering would like to have the bulb and the entire lamp assembly replaced and returned for analysis. If you have any questions, please contact Brigitte Wicks at cell \(248\) 202\-9869. Also please make sure to send the part to Brigitte's attention when it is returned. Thank you.

## The document

- [NHTSA's copy of the document (PDF)](https://static.nhtsa.gov/odi/tsbs/2016/MC-10140230-9999.pdf)
- [If that address does not open, try this one](https://static.nhtsa.gov/odi/tsbs/2016/MC-10140230-0001.pdf)

The document is the manufacturer's. This site does not hold it.

## Components

Lighting

## Vehicles listed

- 2016 RAM 1500
- 2016 RAM 2500

## Other bulletins for the same vehicles and component

- [S2025000001](/bulletins/10247967.md), 2024-01-02, Service bulletin: EXTERIOR LIGHTING; BACK OVER PREVENTION. Malfunction Indicator Lamp Illumination \(MIL\). Diagnostic Trouble Code \(DTC\) P203E ? Reductant Level Sensor 1 Circuit Intermittent\-Erratic Set.
- [L09005H](/bulletins/10235028.md), 2023-04-24, Service bulletin: EXTERIOR LIGHTING:HEADLIGHTS. Headlamp Bulb
- [S2025000001](/bulletins/10234440.md), 2023-04-17, Service bulletin: BACK OVER PREVENTION; EXTERIOR LIGHTING. Malfunction Indicator Lamp Illumination \(MIL\). Diagnostic Trouble Code \(DTC\) P203E ? Reductant Level Sensor 1 Circuit Intermittent\-Erratic Set.
- [S1625000003 Rev.](/bulletins/10231712.md), 2023-02-13, Service bulletin: BACK OVER PREVENTION; EXTERIOR LIGHTING. Malfunction Indicator Lamp \(MIL\) Illumination. NOx Sensor Diagnostic Trouble Codes \(DTCs\) Diagnosis Information.
- [68054772A](/bulletins/10228096.md), 2022-12-19, Service bulletin: EXTERIOR LIGHTING; ELECTRICAL SYSTEM. CABLE ASSY, Power Sliding Backlite For MY16 DS, DJ, DD, DP, D2 trucks. Prior to replacing a Power Sliding Backlight Cable Assembly, please contact Marc Galli by cell phone at \(248\) 941\-8402 as he would like to gather information. In addition, if the dealership is within the Metro Detroit Area, Marc would like to analyze the vehicle in person prior to it being repaired. If Marc cannot be contacted within 15 minutes, please provide pictures of the inside lower rail of the glass to confirm \(2 passenger side and 1 driver side\) cable clips are fully seated as well as pictures of the \(2\) regulator motor cable spring plungers to confirm they are also seated. Then proceed with the repair. Please email pictures to Marc at marc.galli@fcagroup.com.
- [1801517](/bulletins/10224951.md), 2022-10-31, Service bulletin: EXTERIOR LIGHTING; ELECTRICAL SYSTEM; POWER TRAIN; FUEL SYSTEM, DIESEL; SERVICE BRAKES, HYDRAULIC; BACK OVER PREVENTION; FUEL SYSTEM, GASOLINE. Flash: 6.7L Diagnostic and System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module \(ECM/PCM\) with the latest available software. The following Diagnostic Trouble Codes \(DTCs\) have been changed from a one trip fault to a two trip fault:P0421 \- Catalyst 1 Efficiency Below Threshold Bank 1. P2280 \- Air Flow Restriction / Leak Between Air Cleaner And MAF. P203C \- \(Diesel Exhaust Fluid\) Reductant Level Sensor Circuit Low. P208D \- \(Diesel Exhaust Fluid\) Reductant Pump Control Circuit High. A small number of customers may experience a Malfunction Indicator Lamp \(MIL\) illumination. Upon further investigation a technician may find the following DTCs set in the PCM memory:P218F \- Reductant No Flow Detected. P202E \- \(Diesel Exhaust Fluid\) Reductant Injector Performance. U0001\-00 \- CAN C BUS. P24A5 \- EGR Cooler Bypass Bank 1 Control Stuck. P1451 \- Diesel Particulate Filter System Performance. P229E \- NOx Sensor Circuit \- Bank 1 Sensor 2. P0128 \- Thermostat Rationality Improvements. P2281 \- Air Leak Between MAF and Throttle Body. P0218 \- Transmission High Temperature Operation Activated \(68RFE Only\). P0868 \- Line Pressure Low, MIL Action \(68RFE Only\). U110E \- Lost Ambient Temperature Message. P205E \- \(Diesel Exhaust Fluid\) Reductant Tank Temperature Sensor Circuit Intermittent \(setting when the block heater is plugged in\). In addition to addressing the above DTCs, the following powertrain system improvements/enhancements are also included in this software release:Fuel pressure override test improvement for wiTECH. AC pressure sensor error threshold change. No crank, No start fix. Improvement to correct engine feels like low or reduced power. Engine Noise Improvements Improved Engine Fuel Economy. Reduction in engine noise during regeneration at idle. 68RFE Transmission Overall Shift Quality Improvements. Test results fix for partial range misfire \(68RFE Only\). Ambient Air Temperature Improvemen
- [0805016](/bulletins/10224663.md), 2022-10-24, Service bulletin: EXTERIOR LIGHTING:HEADLIGHTS. Headlamps May Be Out Of Adjustment Or Alignment
- [S1625000005](/bulletins/10224028.md), 2022-10-17, Service bulletin: FUEL SYSTEM, DIESEL; AIR BAGS; FUEL SYSTEM, GASOLINE; EXTERIOR LIGHTING. \(Rev. A\) Malfunction Indicator Light \(MIL\) Illuminated. Service Diesel Exhaust Fluid \(DEF\) System ? See Dealer Soon Message on Electronic Vehicle Information Center \(EVIC\) Along With Possible Diagnostic Trouble Code \(DTC\) P241D \- SCR Inducement \- Forced Engine Shutdown.
- [S2025000001](/bulletins/10224024.md), 2022-10-17, Service bulletin: EXTERIOR LIGHTING; BACK OVER PREVENTION. \(Rev. B\) Malfunction Indicator Lamp Illumination \(MIL\). Diagnostic Trouble Code \(DTC\) P203E ? Reductant Level Sensor 1 Circuit Intermittent\-Erratic Set.
- [0809420](/bulletins/10223967.md), 2022-10-17, Service bulletin: EXTERIOR LIGHTING; ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM. Flash: Drivetrain Control Module \(DTCM\) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp \(MIL\) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code \(DTC\) has been set::If the customer has any concerns with the transfer case or if the tech performs any repairs on the transfer case, the software must be updated.C140E \- Transfer Case Motor Blocked. If DTC C140E is present, follow normal diagnostic procedures before updating the DTCM.In addition the customer may describe the following:The ?Service 4WD? message/fault is displayed in the Instrument Panel Cluster \(IPC\). Transfer case shift fork tabs broken during range shift. Noisy \(clunking/ratcheting\) transfer case range shifts. Failure to complete transfer case range shifts. The following software enhancement is available:This update will help reduce premature transfer case failure.

JSON: [/v1/bulletins/10140230](/v1/bulletins/10140230)

[Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%20L09005H%24&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F10140230&vehicle=Service%20bulletin%20L09005H%24)