WenmarOpen by Wenmar Pro

Service bulletin 52029762A$

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10140217
Published by NHTSA2018-06-11
Manufacturer's number52029762A$
Manufacturer's date2016-03-23
NHTSA componentFUEL SYSTEM, DIESEL

NHTSA's summary

Urea tank shell Trucks equipped with a 6.7L Cummins Turbo Diesel only; If vehicle comes in with a P207F DTC, record the following information to be shared with the engineer. All Active and Inactive P-Codes~ - Refractometer concentration~ - WiTech Concentration~ - WiTech Concentration Sensor Temperature ~ - Urea Tank Temperature~ - Urea Tank level when fault was set~ - Hydrocarbon reading~ - Known fill history before and after the fault was set~ - Recent weather conditions in the area~ - Actions Taken since vehicle had been brought to the dealership ~ Please contact Gary Pleyte at cell (248) 705-3567 or Makenna Coe Smith at cell (248) 202-7545 with the above information. If you are unable to get a response within 15 mins, please continue with the repair according to the trouble tree for P207F.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Fuel system

Trouble codes named

P207F

Vehicles listed
RAM 25002015, 2016
RAM 35002015, 2016

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Other bulletins for the same vehicles and component
1813022REVA2023-01-17. Service bulletin. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs: P20EE - SCR NOx Catalyst Efficiency Below Threshold - Bank 1. P1C54 - SCR NOx Catalyst Missing. P229F - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 2. P207F - Reductant Quality Performance. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P2201 - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 1. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. P0300 - Multiple Cylinder Misfire. P0301-00 - Cylinder 1 Misfire. P0302-00 - Cylinder 2 Misfire. P0303-00 - Cylinder 3 Misfire. P0304-00 - Cylinder 4 Misfire. P0305-00 - Cylinder 5 Misfire. P0306-00 - Cylinder 6 Misfire. P249E - Closed Loop SCR Reductant Injection Control At Limit - Flow Too High. P0128 - Thermostat Rationality. P218F - Reductant No Flow Detected. U0001-00 - CAN C BUS. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P0218 - Transmission High Temperature Operation Activated (68RFE Only). P0868 - Line Pressure Low, MIL Action (68RFE Only). U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). The following DTCs have been changed from a one trip fault to a two trip fault:P0421 - Catalyst 1 Efficiency Below Threshold Bank 1. P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. In addition to addressing the above DTCs,
25001152023-01-09. Service bulletin. Diesel Exhaust Fluid (DEF) Level Gauge Inaccurate Or Stuck This bulletin involves verifying the correct DEF level in the tank and if necessary, replacing the DEF pump module. A small number of customers may comment that their DEF level gauge is stuck for long periods of time or is erratic. The customer may also experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find one or more of the following Diagnostic Trouble Codes (DTCs). ? P203B - Reductant Level Sensor Circuit Performance ? P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. ? P203D - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit High.
1802716REVB2022-12-19. Service bulletin. Flash: 6.7L Diagnostic And System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The following DTCs have been changed from a one trip fault to a two trip fault: · P0421 - Catalyst 1 Efficiency Below Threshold Bank 1. · P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. · P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. · P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find the following DTCs set in the PCM memory: · **P0128 - Thermostat Rationality Improvements.** · P2281 - Air Leak Between MAF and Throttle Body. · P218F - Reductant No Flow Detected. · P0218 - Transmission High Temperature Operation Activated (68RFE Only). · P0868 - Line Pressure Low, MIL Action (68RFE Only). · U110E - Lost Ambient Temperature Message. · P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). In addition to addressing the above DTCs, the following powertrain system improvements/enhancements are also included in this software release: · **Engine Noise Improvements. · Engine Hesitation Improvement. · Improved Engine Fuel Economy.** · Reduction in engine noise during regeneration at idle. · 68RFE Transmission Overall Shift Quality Improvements. · Test results fix for partial range misfire (68RFE Only). · Ambient Air Temperature Improvements. · Stationary Desoot with wiTECH Fix. · OBD Misfire Monitoring Improvement (68RFE Only).
18076222022-12-19. Service bulletin. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain ControlModule (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find one or more of thefollowing DTCs have been set: P064F - Unauthorized Software/Calibration Detected. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1C55 - NOx Sensor Intermittent ? Bank 1 Sensor 1. P0301 - Cylinder 1 Misfire. P0302 - Cylinder 2 Misfire. P0303 - Cylinder 3 Misfire. P0304 - Cylinder 4 Misfire. P0305 - Cylinder 5 Misfire. P0306 - Cylinder 6 Misfire. P020A - Fuel Injector 1 Performance. P020B - Fuel Injector 2 Performance. P020C - Fuel Injector 3 Performance. P020D - Fuel Injector 4 Performance. P020E - Fuel Injector 5 Performance. P020F - Fuel Injector 6 Performance. U0001 - Can C Bus. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P218F - Reductant No Flow Detected. P242F - Diesel Particulate Filter Restriction - Ash Accumulation. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor CircuitIntermittent (setting when the block heater is plugged in). U110E - Lost Ambient Temperature Message. P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. P2281 - Air Leak Between MAF And Throttle Body. P1477 - Intake Air Diverter Valve Position Sensor Circuit Shorted To Ground. U1421 - Implausible Ignition Key Off Time Received. P026B - Injection Timing Performance. In addition, the following software enhancements are also available: A/C pressure sensor update. Improvements made to reduce misfire. wiTECH engine cooling fan actuation test update. Improved Exhaust Gas Recirculation (EGR) valve response. Over Running Clutch (ORC) software improvement. Unpleasantodor in the vehicle at low speeds during regeneration cycle.
25001162022-11-21. Service bulletin. Diagnosing A Urea Module That Is Exposed To Diesel Fuel This bulletin involves discussing what will happen to the rubber material used in the urea pump when exposed to diesel fuel. This unit is sometimes referred to as the Selective Catalyst Reductant (SCR) module or the Adblue Delivery Module (ADM). Units exposed to hydrocarbons have a particular failure mode, the rubber heater unit is crinkled and in some cases the metal heater protrudes through the rubber membrane. The rubber material used in this unit is designed to withstand Diesel Exhaust Fluid (DEF) only. Exposure to fluids that contain hydrocarbons (i.e. diesel fuel) will damage the unit beyond repair. Units returned that exhibit this failure mode will have warranty claims that are rejected. Units that exhibit this failure mode should be considered customer abuse and should not be covered under warranty. Use the Hydroscopic test paper (P/N 223-44-863) available through MoparEssentialTools.com to confirm exposure.
S22140000032022-11-07. Service bulletin. Guidelines For The Use Of Alternative Diesel Fuels.
18015172022-10-31. Service bulletin. Flash: 6.7L Diagnostic and System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The following Diagnostic Trouble Codes (DTCs) have been changed from a one trip fault to a two trip fault:P0421 - Catalyst 1 Efficiency Below Threshold Bank 1. P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find the following DTCs set in the PCM memory:P218F - Reductant No Flow Detected. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. U0001-00 - CAN C BUS. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P0128 - Thermostat Rationality Improvements. P2281 - Air Leak Between MAF and Throttle Body. P0218 - Transmission High Temperature Operation Activated (68RFE Only). P0868 - Line Pressure Low, MIL Action (68RFE Only). U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). In addition to addressing the above DTCs, the following powertrain system improvements/enhancements are also included in this software release:Fuel pressure override test improvement for wiTECH. AC pressure sensor error threshold change. No crank, No start fix. Improvement to correct engine feels like low or reduced power. Engine Noise Improvements Improved Engine Fuel Economy. Reduction in engine noise during regeneration at idle. 68RFE Transmission Overall Shift Quality Improvements. Test results fix for partial range misfire (68RFE Only). Ambient Air Temperature Improvemen
1802716REVA2022-10-24. Service bulletin. Flash: 6.7L Diagnostic And System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. DTCs have been changed from a one trip fault to a two trip fault: · **P0421 - Catalyst 1 Efficiency Below Threshold Bank 1.** · P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. · P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. · P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: · P2281 - Air Leak Between MAF and Throttle Body. · P218F - Reductant No Flow Detected. · P0218 - Transmission High Temperature Operation Activated (68RFE Only). · P0868 - Line Pressure Low, MIL Action (68RFE Only). · U110E - Lost Ambient Temperature Message. · P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). In addition to addressing the above DTCs, the following powertrain system improvements/enhancements are also included in this software release: · **Reduction in engine noise during regeneration at idle.** · 68RFE Transmission Overall Shift Quality Improvements. · Test results fix for partial range misfire (68RFE Only). · Ambient Air Temperature Improvements. · Stationary Desoot with wiTECH Fix. · OBD Misfire Monitoring Improvement (68RFE Only).
18-039-162022-10-24. Service bulletin. Flash: 6.7L Diagnostic And System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. These DTCs have been changed from a one trip fault to a two trip fault: · P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. · P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. · P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: · P1C55 - NOx Sensor Intermittent - Bank 1 Sensor 1. · P207F - Reductant Quality Performance. · P218F - Reductant No Flow Detected. · U110E - Lost Ambient Temperature Message. In addition to addressing the above DTCs, the following powertrain system improvements/enhancements are also included in this software release: · Ambient Air Temperature Improvements. · Stationary de-soot with WiTech fix.
18-038-162022-10-24. Service bulletin. P20EE SCR NOX Catalyst Efficiency Below Threshold Bank 1 This bulletin involves verifying the proper operation of the Diesel Exhaust Fluid (DEF) system and, if necessary, replacing the Selective Catalyst Reduction (SCR) Catalyst assembly. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find Diagnostic Trouble Code (DTC) P20EE SCR NOX Catalyst Efficiency Below Threshold Bank 1 set in the Powertrain Control Module (PCM) memory.