# Service bulletin R73

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

- Type: Service bulletin
- NHTSA id: 10119608
- Published by NHTSA: 2017\-10\-21
- Manufacturer's number: R73
- Manufacturer's date: 2016\-08\-01
- NHTSA component: WHEELS

## NHTSA's summary

Customer Satisfaction Notification R73 Wheel Stud Wrench The wheel stud wrench on about 11,700 of the above vehicles may break during use due to a non\-compliant heat treatment process causing the material hardness to be out of specification. The wheel stud wrench must be replaced on the affected vehicles.

## The document

- [NHTSA's copy of the document (PDF)](https://static.nhtsa.gov/odi/tsbs/2016/MC-10119608-9999.pdf)
- [If that address does not open, try this one](https://static.nhtsa.gov/odi/tsbs/2016/MC-10119608-0001.pdf)

The document is the manufacturer's. This site does not hold it.

## Components

Wheels

## Vehicles listed

- 2016 FIAT 500X
- 2015 to 2016 JEEP RENEGADE

## Other bulletins for the same vehicles and component

- [0801016](/bulletins/10228143.md), 2022-12-19, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE \(TCM/PCM/TECM\); FUEL SYSTEM, GASOLINE; ELECTRICAL SYSTEM; WHEELS. Flash: Diagnostic And System Improvements This bulletin involves updating the Body Control Module \(BCM\), Powertrain Control Module \(PCM\) and Transmission Control Module \(TCM\) with the latest available software. All three modules must be updated in this service action. Powertrain Control Module \(PCM\) Customers may experience a Malfunction Indicator Lamp \(MIL\) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes \(DTCs\): · U1424\-00 \- Implausible Engine Torque Signal Received. · P0335 \- Crankshaft Position Sensor Circuit. · P1185 \- General Pressure Sensor Correlation. · P050D \- Cold Start Rough Idle. · P1CEC \- Variable Valve Solenoid Valve Cold Start Closing Position 1 Timing Over\-Retard. · P1CED \- VAriable Valve Timing Solenoid Valve Cold Start Closing Position Timing Over\-Advance. · P1607 \- PCM Internal Shutdown Timer Rationality. · P2610 \- PCM Internal Engine Off Timer Performance. · P0440 \- General EVAP System Failure. · P0441 \- EVAP Purge System Performance. · P0456 \- EVAP System Small Leak. · P0455 \- EVAP System Large Leak. · P0452 \- EVAP Pressure Switch Stuck Closed. · P0133 \- O2 Sensor 1/1 Slow Response. · C0501 \- Wheel Speed Signal Left Front Rationality. · C0507 \- Wheel Speed Signal Right Front Rationality. · C050D \- Wheel Speed Signal Left Rear Rationality. · C0513 \- Wheel Speed Signal Right Rear Rationality. · U0428\-00 \- Implausible Data Received From Steering Angle Sensor Module. · P1185 \- General Pressure Sensor Correlation. · C0061 \- Lateral Acceleration Sensor. · P0128 \- Thermostat Rationality. · C0501 \- Wheel Speed Signal Left Front Rationality. · C0507 \- Wheel Speed Signal Right Front Rationality. · C050D \- Wheel Speed Signal Left Rear Rationality. · C0513 \- Wheel Speed Signal Right Rear Rationality. · C0062 \- Longitudinal Acceleration Sensor In Airbag System \- Signal Invalid.
- [2200216](/bulletins/10228121.md), 2022-12-19, Service bulletin: WHEELS. Rust On Wheel Lug Studs This bulletin involves replacing the wheel lug studs with the newer capped studs. The customer may describe the lug studs are rusting.
- [0808417](/bulletins/10224767.md), 2022-10-24, Service bulletin: ELECTRICAL SYSTEM; EXTERIOR LIGHTING; WHEELS; SERVICE BRAKES; AIR BAGS; SEAT BELTS. Flash: Radio Frequency Hub Module \(RFHM\) Enhancements This bulletin involves reprogramming the RFHM with the latest available software. Customers may experience a Malfunction Indicator Lamp \(MIL\) illumination. Upon further investigation the technician may find that the following DTC has been set:B1053\-64 RFHM \(Keyless Ignition Node \(KIN\) Communication\) \- Signal Plausibility Failure \(Software has been updated to better addressthis DTC\). In addition, the customer may notice the following condition\(s\):With the ignition in the run position and the engine not running, the vehicle may not turn itself off after 30 minutes. Doors may not unlock when using the Remote Keyless Entry \(RKE\) Fob. \(2015 only\) Tire pressure monitoring \(TPM\) light may illuminate when using the winter tires in winter mode functionality. \(2015\-2016 only\) After an engine start and the doors are closed, a message in the cluster may be displayed ?Key Not Detected? when the key is actually present. \(2015\-2016 only\) Only a message is displayed, the vehicle will start.
- [0806421](/bulletins/10221211.md), 2022-09-26, Service bulletin: ELECTRICAL SYSTEM; SERVICE BRAKES, HYDRAULIC; WHEELS; ELECTRICAL SYSTEM:SOFTWARE; EXTERIOR LIGHTING; SEAT BELTS; AIR BAGS. Flash: Radio Frequency Hub Module \(RFHM\) Enhancements This bulletin involves reprogramming the RFHM with the latest available software. Customers may experience a Malfunction Indicator Lamp \(MIL\) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code \(DTC\) has been set:B1053\-64 RFHM \(Keyless Ignition Node \(KIN\) Communication\) \- Signal Plausibility Failure \(Software has been updated to better address this DTC\). In addition, the customer may notice the following condition\(s\): Service Passive Entry Light" on cluster and MIL code B1053\-64. Vehicle will not shut off with DTC B1053\-64. Vehicle may not start with DTC B1053\-64. With the ignition in the run position and the engine not running, the vehicle may not turn itself off after 30 minutes. Doors may not unlock when using the Remote Keyless Entry \(RKE\) Fob.\(2015 only\) Tire pressure monitoring \(TPM\) light may illuminate when using the winter tires in winter mode functionality.\(2015\-2016 only\) After an engine start and the doors are closed, a message in the cluster may be displayed ?Key Not Detected? when the key is actually present.\(2015\-2016 only\) Only a message is displayed, the vehicle will start.
- [22\-004\-16](/bulletins/10217610.md), 2022-08-08, Service bulletin: TIRES; WHEELS. Wheel Clicking Sound When Moving Slow This bulletin involves replacing the inserts attached to the wheel. The customer may describe a clicking sound from the wheels plastic trim inserts when moving slowly or when stopped. The issue is heard on sunny days when the sun heats up the wheels and plastic inserts.
- [21\-038\-15 REV. B](/bulletins/10217418.md), 2022-08-08, Service bulletin: WHEELS; AIR BAGS; ELECTRICAL SYSTEM. Flash: Drivetrain Control Module \(DTCM\) C2020\-01 ECU Internal Fault setting in the DTCM This bulletin involves reprogramming the Drivetrain Control Module \(DTCM\) with the latest available software. Some vehicles may experience the All Wheel Drive Light \(AWD\) illuminating due to DTC C2020\-01 ECU Internal Fault setting erroneously in the DTCM.
- [21\-038\-15 REV. A](/bulletins/10217397.md), 2022-08-08, Service bulletin: ELECTRICAL SYSTEM; AIR BAGS; WHEELS. Flash: Drivetrain Control Module \(DTCM\) C2020\-01 ECU Internal Fault setting in the DTCM This bulletin involves reprogramming the Drivetrain Control Module \(DTCM\) with the latest available software. Some vehicles may experience the All Wheel Drive Light \(AWD\) illuminating due to DTC C2020\-01 ECU Internal Fault setting erroneously in the DTCM.
- [21\-048\-15 REV. A](/bulletins/10217396.md), 2022-08-08, Service bulletin: AIR BAGS; ELECTRICAL SYSTEM; WHEELS. Flash: Drivetrain Control Module C2020\-01 ECU Internal Fault setting in the DTCM This bulletin involves reprogramming the Drivetrain Control Module \(DTCM\) with the latest available software. Some vehicles may experience the All Wheel Drive Light \(AWD\) illuminating due to DTC C2020\-01 ECU Internal Fault setting erroneously in the DTCM.
- [05\-010\-15](/bulletins/10217387.md), 2022-08-08, Service bulletin: SERVICE BRAKES; AIR BAGS; BACK OVER PREVENTION; WHEELS. Front Brake Squeak/Squeal Noise This bulletin involves cleaning excessive sealant from the front brake caliper adaptor brackets and replacing the adaptor bracket mounting bolts and/or replacing the front brake pads and related hardware. The customer may describe one or more of the front brake squeak/squeal noise symptoms/conditions: ? Squeak/squeal noise during moderate brake apply combined with light steering. The noise typically occurs with warm brakes after several brake applications. ? Squeak/squeal noise during low speed brake apply with vehicle moving forward or reverse. The noise typically only occurs after the vehicle sits overnight in colder ambient temperatures and the noise will go away after a few brake applications.
- [21\-038\-15 REV. B](/bulletins/10216180.md), 2022-07-25, Service bulletin: AIR BAGS; ELECTRICAL SYSTEM; WHEELS. Flash: Drivetrain Control Module \(DTCM\) C2020\-01 ECU Internal Fault setting in the DTCM This bulletin involves reprogramming the Drivetrain Control Module \(DTCM\) with the latest available software. Some vehicles may experience the All Wheel Drive Light \(AWD\) illuminating due to DTC C2020\-01 ECU Internal Fault setting erroneously in the DTCM.

JSON: [/v1/bulletins/10119608](/v1/bulletins/10119608)

[Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%20R73&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F10119608&vehicle=Service%20bulletin%20R73)