Service bulletin ICI16-027
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10119487 |
| Published by NHTSA | 2017-10-15 |
| Manufacturer's number | ICI16-027 |
| Manufacturer's date | 2016-12-02 |
| NHTSA component | EQUIPMENT; SEAT BELTS |
NHTSA's summary
ICI16-027 FL725 ? Interim Recall Notice
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Equipment and accessories, Seat belts
| WESTERN STAR 4900 | 2014 |
|---|---|
| WESTERN STAR 5700 | 2014 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2017636 | 2017-12-18. Accessories |
|---|---|
| 17V810000 | 2017-12-15. EQUIPMENT |
| 16V711000 | 2016-10-05. SEAT BELTS |
| 2016483 | 2016-10-04. Seats And Restraints |
| 15V182000 | 2015-03-27. EQUIPMENT |
| 2015133 | 2015-03-25. Accessories |
| 14V150000 | 2014-03-28. SEAT BELTS |
| 13V604000 | 2013-11-29. SEAT BELTS |
| 13V401000 | 2013-09-05. SEAT BELTS:FRONT:ANCHORAGE |
| 2013300 | 2013-09-04. Seats And Restraints |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| WSTCAE180-2020 | 2021-05-18. Service bulletin. Portland Truck Plant Paint Changes |
|---|---|
| WI21-008 | 2021-04-23. Service bulletin. Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021. |
| DT12 Trans Chafe | 2021-04-08. Service bulletin. DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to be causing issues to the After Treatment Control Module (ACM). These fault codes indicated that the ACM communication message was not received by the Motor Control Module (MCM) which in certain cases, led to a 25% engine de-rate situation. Further diagnosis revealed that the DT12 wiring harness was chafing and contacting the transmission TCU case. To reduce potential chafing areas, the proposed short-term containment was to route the wiring harness using additional tie straps. This communication applies to Freightliner and Western Star vehicles built with DT12 transmissions. |
| WP60-100 | 2021-03-25. Service bulletin. Updated Western Star Parts Technical Bulletin for Universal Design Floor Mats. This bulletin replaces the version dated February 12, 2021. Information about parts notes in the Paragon system have been added and the trimming instructions are revised. Universal floor mat designs fit multiple cab configurations and may require trimming. Trim lines displaying size options are scored into the pad side of the mat; use an existing floor mat as a guide for optimal results. The new mat should not interfere with safety-critical equipment, such as foot pedals. |
| SBW54-057 | 2021-03-25. Service bulletin. Western Star Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. When troubleshooting powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues. |
| WP60-100 | 2021-02-27. Service bulletin. Western Star Parts Technical Bulletin for Universal Design Floor Mats. Universal floor mat designs fit multiple cab configurations and may require trimming. Trim lines displaying size options are scored into the pad side of the mat; use an existing floor mat as a guide for optimal results. The new mat should not interfere with safety-critical equipment, such as foot pedals. |
| WP20-018 | 2020-12-12. Service bulletin. Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply. |
| 18SP744 | 2020-12-08. Service bulletin. Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines Service Kit. |
| JOYSON LTR | 2020-11-01. Service bulletin. Joyson Safety Systems letter informing DTNA about Hikone Webbing Investigation. JSS is near completion of an initial investigation regarding data integrity issues at the seatbelt webbing manufacturing facility in Hikone, Japan acquired from Takata in April of 2018. |
| TechTalk4725 | 2020-09-30. Service bulletin. Tech Talk discussion about power steering fluid. |