Service bulletin TT066

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
Type	Service bulletin
NHTSA id	10089848
Published by NHTSA	2017-01-30
Manufacturer's number	TT066
Manufacturer's date	2015-05-27
NHTSA component	ELECTRICAL SYSTEM; VEHICLE SPEED CONTROL

NHTSA's summary

"TECH TIP: DTC C1203 OR C1212 - SPEED SENSOR FAILURE SYMPTOM: C1203 – RH FRONT WHEEL SPEED SENSOR OPEN/SHORT AND/OR C1212 – VEHICLE SPEED SENSOR FAILURE. REPAIR: CHECK FOR A SHORT IN THE MAIN ESC HARNESS NEAR THE RADIATOR BRACKET. VERIFY POSSIBLE RUBBING BETWEEN THE BRACKET THAT RUNS UNDER THE HEADLIGHT TO THE RADIATOR AND THE HARNESS (SEE IMAGE). REPAIR THE DAMAGED WIRES AND ADD INSULATION TO THE BRACKET TO PREVENT ANY FURTHER DAMAGE TO THE HARNESS. CLEAR ANY DTCS (IN ACTIVE OR HISTORY). "

The document

No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.

Components

Electrical system, Throttle and cruise control

Trouble codes named

C1203, C1212

Vehicles listed
KIA OPTIMA HYBRID	2015 (the catalog's model; the bulletin names a series or trim of it)

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
2023275	2023-05-08. Electrical

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
TSB_CLI049_R2	2026-09-02. Service bulletin. TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR – ELECTRICAL A/C COMPRESSOR - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Air Conditioning (A/C) compressor assembly on some 2011MY~ Optima Hybrid (TF HEV, JF HEV/PHEV), 2015MY~ Soul EV (PS EV), 2017MY~ Niro (DE HEV/PHEV/EV), 2022MY~ EV6 (CV), 2021MY~ Sorento (MQ4 HEV/PHEV), 2023MY~ Sportage (NQ5 HEV/PHEV), and 2023MY~ Niro (SG2 EV/HEV/PHEV) vehicles.
SC269_OWNR_401	2026-07-21. Service campaign. VOLUNTARY SERVICE CAMPAIGN: OWNER RENOTIFICATION (SC269 FLIGHT #401) - This document is the owner renotification advising that Kia is conducting a Voluntary Service Campaign to inspect and, if necessary, replace the high-voltage fuse in 2013-2016 MY Optima Hybrid vehicles.
PI2104_OWNR_501	2026-03-31. Other. PRODUCT IMPROVEMENT CAMPAIGN: OWNER RENOTIFICATION (PI2104 FLIGHT 501) - This document is the owner renotification advising that Kia is conducting a Product Improvement Campaign to perform a software update on 2014-2016 MY Optima Hybrid vehicles equipped with 2.4-liter MPI engines to protect the engine from excessive connecting rod bearing damage. The update will be done free of charge and will only involve the addition of newly developed computer software for the Engine Control Unit (“ECU”).
PI2104_OWNR_401	2025-07-23. Other. PRODUCT IMPROVEMENT CAMPAIGN: OWNER RENOTIFICATION (PI2104) - This document is the owner renotification advising that Kia is conducting a Product Improvement Campaign to perform a software update on 2014-2016 MY Optima Hybrid vehicles equipped with 2.4-liter MPI engines to protect the engine from excessive connecting rod bearing damage. The update will be done free of charge and will only involve the addition of newly developed computer software for the Engine Control Unit (“ECU”).
SC269_OWNR_301	2025-03-26. Service campaign. VOLUNTARY SERVICE CAMPAIGN: OWNER RENOTIFICATION (SC269) - This document is the owner renotification advising that Kia conducting a Voluntary Service Campaign to inspect and, if necessary, replace the high-voltage fuse in 2013-2016 MY Optima Hybrid vehicles.
SC269_TSB_R1	2024-08-21. Service bulletin. TECHNICAL SERVICE BULLETIN: VOLUNTARY SERVICE CAMPAIGN: HIGH-VOLTAGE BATTERY SAFETY PLUG FUSE INSPECTION AND REPLACEMENT (SC269) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect and, if necessary, replace the High Voltage Battery (HVB) Safety Plug Fuse Assembly or Main Fuse on 2013-2016MY Optima Hybrid (TF HEV) vehicles produced from September 27, 2012 through July 22, 2015. The high-voltage fuse in the subject vehicles may have been replaced with an improper non-OEM aftermarket fuse by third-party repair facilities. A fuse of incorrect capacity may experience a shortened service life, which may result in illumination of the “Hybrid System Warning” and/or “Check Engine Light,” followed by a no-start condition. If an improper non-OEM aftermarket fuse is installed, it may fail and result in a fire.
SC269_OWNR_F2	2024-08-14. Service campaign. VOLUNTARY SERVICE CAMPAIGN: OWNER RENOTIFICATION (SC269) - This document is the owner renotification advising that Kia is conducting a Voluntary Service Campaign to inspect and, if necessary, replace the high-voltage fuse in 2013-2016 MY Optima Hybrid vehicles.
CS2303_TSB_R4	2024-06-13. Service bulletin. TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2303) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2011-2015MY Optima (TF), 2012-2015MY Optima (QF) and 2016-2020MY Optima (JF, JFa) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked with the use of the key fob.
PI1802YZ_TSB_R7	2024-04-03. Service bulletin. TECHNICAL SERVICE BULLETIN: PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published PI1802 titled "Knock Sensor Detection System - ECU Logic Improvement"; equipped w/THETA II engine. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
CS2310_TSB_R1	2023-08-24. Service bulletin. TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: KIA GENUINE REMOTE START CONTROL MODULE UPGRADE FOR ANTI-THEFT LOGIC COMPATIBILITY (CS2310) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software logic in the Kia Genuine Remote Start Control Module on certain 2012-2022MY model vehicles listed on page 7. Vehicles equipped with a Kia Genuine Remote Start feature and have had the Anti-Theft software logic (CS230*) applied to the Integrated Body Control Unit (IBU) or Body Control Module (BCM) may experience five (5) inadvertent honks after starting the vehicle with the remote start feature.