Service bulletin G-208451
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10079366 |
| Published by NHTSA | 2016-09-07 |
| Manufacturer's number | G-208451 |
| Manufacturer's date | 2015-01-14 |
| NHTSA component | AIR BAGS |
NHTSA's summary
14546 - CUSTOMER SATISFACTION PROGRAM. CERTAIN 2009-2010 MODEL YEAR CHEVROLET HHR VEHICLES MAY HAVE A PASSENGER AIR BAG IN-LINE JUMPER WIRING HARNESS CONNECTOR WITH FRETTING CORROSION AT THE TERMINAL CONTACTS. FRETTING CORROSION COULD CAUSE AN INCREASE IN THE SYSTEM DEPLOYMENT LOOP RESISTANCE. THE VEHICLE’S SENSING AND DIAGNOSTIC MODULE MAY INTERPRET THIS INCREASE IN RESISTANCE AS A FAULT WHICH WILL ILLUMINATE THE AIR BAG LIGHT ON THE VEHICLE INSTRUMENT PANEL AND SET DIAGNOSTIC TROUBLE CODES B0019 AND/OR B0020. IF THIS CONDITION IS NOT CORRECTED AND THE RESISTANCE IN THE CONNECTOR REACHES A HIGH ENOUGH LEVEL, THE PASSENGER AIRBAG MAY NOT DEPLOY IN THE EVENT OF A VEHICLE CRASH. DEALERS ARE TO REPLACE THE UNSEALED CONNECTOR WITH A SEALED CONNECTOR.
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Air bags
Trouble codes named
B0019, B0020
| CHEVROLET HHR | 2009 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 14V047000 | 2014-02-10. AIR BAGS; ELECTRICAL SYSTEM:IGNITION:SWITCH |
|---|
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| PIC5650J | 2021-09-13. Service bulletin. This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, and/or B3935. Technician should not replace any parts for this concern. If unable to duplicate the concern ask if the customer uses any Radio Frequency Identification Devices when the concern is present. Dealer should also direct their customers to the appropriate section in the Owner manuals that references that the device complies. |
|---|---|
| 08-09-41-002H | 2018-05-21. Service bulletin. This technical bulletin provides a procedure to complete a terminal replacement or connector re connection to correct a condition of Diagnostic Information for Supplemental Inflatable Restraint (SIR) System, Intermittent AIR BAG Indicator/Lamp Illuminated with DTC(s) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 or B0044 Set (Inspect and Replace Connector Position Assurance (CPA) Retainer) |
| 14314 | 2018-04-23. Service bulletin. 14314 - Special Coverage. Certain 2009 Chevrolet Cobalt, Pontiac G5, Solstice, Saturn Sky, and 2008-2009 Chevrolet HHR SS vehicles may have a condition in which the steering wheel airbag coil wires to the driver airbag may become chafed on a sharp edge of the steering wheel horn plate. In vehicles with this condition, the airbag indicator lamp may be continuously or intermittently illuminated in the instrument panel cluster, and DTC codes B0012 or B0013 may be stored in the Supplemental Inflatable Restraint (SIR) system. If this condition is not corrected and a chafed wire were to ground to the horn plate, the driver airbag may not deploy in the event of a vehicle crash. Dealers are to install woven polyester electrical tape (PET) tape around the two yellow SIR wires and the metal horn plate to prevent a grounding condition from developing. Also, if the airbag coil wires are determined to be damaged, dealers are to replace the steering wheel airbag coil. |
| 06-08-50-009I | 2017-08-15. Service bulletin. This informational bulletin provides Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices |
| SB-08-09-41-007I | 2016-04-26. Service bulletin. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| SC-14314 | 2015-06-17. Service bulletin. CHEVROLET/PONTIAC/SATURN: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. DRIVER SIDE AIRBAG, ON A SHARP EDGE OF STEERING WHEEL HORN PLATE, WILL BECOME CHAFED DUE TO STEERING WHEEL AIRBAG COIL WIRES AND CAUSES AIRBAG NOT TO DEPLOY, IF NOT CORRECTED. MODEL 2008-09 HHR SS, 2009 COBALT, G5, SOLSTICE, SKY. *PE |
| 14546 | 2015-05-08. Service bulletin. CHEVROLET HHR:2009-2010 PASSENGER AIR BAG WIRING HARNESS CONNECTOR: CERTAIN VEHICLES AIRBAGS CAN CAUSE CORROSION. *LJ SEE DOCUMENT SEARCH BUTTON FOR OWNERS LETTER. *LJ |
| 08-09-41-007G | 2012-04-28. Service bulletin. PASSENGER PRESENCE SYSTEM (PPS) MAY COMMAND PASSENGER AIRBAG INDICATOR AND SEAT BELT REMINDER ON WHEN ELECTRONIC DEVICES (COMPUTERS, MP3 PLAYERS, CELL PHONES, DIAGNOSTIC SCAN TOOL, ETC.) ARE PLACED ON FRONT PASSENGER SEAT, DTCS 5045 OR B0074 0F SET IN PPS MODULE. *JS UPDATED 2/21/13. *PE |
| PI-0117A | 2011-12-05. Service bulletin. CHEVROLET: BULLETIN IS INREGARDS TO INFORMATION CONCERNING THE INSTRUMENT PANEL CLUSTER (IPC), WHERE THE SIR/AIRBAG INDICATOR/LIGHT WOULD BE ON. *PE UPDATED ON 5/1/2012. *KB |
| 08-09-41-007D | 2011-06-14. Service bulletin. GM: THE FRONT PASSENGER AIRBAG INDICATOR MAY LIGHT WHEN ELECTRONICS ARE PLACED IN THE PASSENGER SEAT. THE ELECTRONICS CAUSE THE VEHICLE TO THINK THERE IS A PASSENGER SITTING IN THE SEAT. *RM UPDATED 6/24/11. *PE |