Service bulletin TJ 31408
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10075256 |
| Published by NHTSA | 2016-06-22 |
| Manufacturer's number | TJ 31408 |
| Manufacturer's date | 2016-03-31 |
| NHTSA component | TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS |
NHTSA's summary
2016 XC90 D-TPMS, Low tire pressure warning Tires/Slow leaks 21 Warning lights and chimes/Tire pressure monitoring, Low tire pressure warning If the vehicle is equipped with direct tire pressure monitoring sensors (D-TPMS) and there is a warning message in the DIM about Low tire pressure, follow advice under Service. In case there is a TPMS warning message in DIM about Low tire pressure: • Check tire pressure on the concerned wheel to confirm the symptom. Note: Refer to Tire label on B-pillar for the correct tire pressure. • If the tire pressure is low, check that there are no visible damages or screws / nails in the tire. • If the tire is defective, have it replaced. • Place some soap water between the air valve and rim to check if there are any bubbles at the air valve. Note: also push the air valve sideways to see if there are any air leaks when valve is not in centre position. • If leak/bubbles are found at the air valve, pull up the air valve one or few millimetres using tire valve tool until the air leak stops. • If air valve is defective or if the leak continues after pulling up the air valve, then check and eventually replace the air valve with a service air valve PN 31400856. • Once tires are not leaking and have the correct tire pressure, initiate a D-TPMS calibration and road test vehicle.
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Tires, Tire pressure monitoring
| VOLVO XC90 | 2016 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| TJ31408 | 2021-12-27. Service bulletin. 2016 XC90 D-TPMS, Low tire pressure warning. |
|---|---|
| TJ31398 | 2021-12-27. Service bulletin. 2016 XC90 D-TPMS, service required and DTC's. |
| TJ31398.5.0-2021 | 2021-03-15. Service bulletin. This is a Technical Journal: D-TPMS, Service required and DTC's |
| TJ34803.2.0-2020 | 2020-11-23. Service bulletin. This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. The calibration function itself is not changed compared to previous SW versions, it is only how it is presented in the center display that has been changed.A new calibration will start automatically as soon as the VDDM SW is upgraded. |
| TJ29818 9 0-2019 | 2019-09-23. Service bulletin. This is a Technical Journal: If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow advice under Service. |
| TJ3480310-2019-0 | 2019-07-01. Service bulletin. This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. The calibration function itself is not changed compared to previous SW versions, it is only how it is presented in the center display that has been changed.A new calibration will start automatically as soon as the VDDM SW is upgraded. |
| TJ3386430-2019-0 | 2019-07-01. Service bulletin. This is a Technical Journal: It may happen that after a software download, the TPMS light is flashing and DTC VDDM-U24004A, "ECU Software. System internal failures" is set. This is due to that the I-TPMS function in VDDM has not been initialized. |
| TJ29818 | 2019-04-08. Service bulletin. This is a Technical Journal: If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow advice under Service. |
| TJ29818 | 2019-04-01. Service bulletin. This is a Technical Journal: If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow advice under Service. |
| TJ29818 | 2018-10-29. Service bulletin. This is a Technical Journal: If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow advice under Service. |