Service bulletin T-SB-0192-11

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
Type	Service bulletin
NHTSA id	10060780
Published by NHTSA	2016-03-31
Manufacturer's number	T-SB-0192-11
Manufacturer's date	2011-12-13
NHTSA component	SEATS

NHTSA's summary

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

The document

No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.

Components

Seats

Vehicles listed
TOYOTA SIENNA	2011, 2012, 2013, 2014

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
16V396000	2016-06-02. SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
14V743000	2014-11-19. SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
13V014000	2013-01-16. SEATS; AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
2011123	2011-03-18. Seats And Restraints

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
T-SB-0012-21 Rev	2022-03-14. Service bulletin. TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk. Follow the Repair Procedure in this bulletin to address this condition
T-SB-0012-21	2021-04-19. Service bulletin. TSB: Some 2010 ? 2021 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk. Follow the Repair Procedure in this bulletin to address this condition.
T-SB-0180-12 Rev	2018-12-17. Service bulletin. TSB: December 2, 2015: This bulletin is now obsolete. Please see T-SB-0118-15.
T-SB-0118-15	2018-12-17. Service bulletin. TSB: Some 2011 ? 2015 model year Sienna vehicles may exhibit a condition where the driver side 2nd row seat with the tip-up style lower seat cushion has excessive up and down movement. While some seat movement is a normal characteristic of the design, this bulletin will help identify excessive movement and provide steps to address this condition.
TS-WI-0290	2018-09-17. Service bulletin. Service Bulletin sent to all dealers to inspect L-track bolts for correct torque and to incorporate torque check as part of regular maintenance
T-SB-0207-17	2018-07-02. Service bulletin. TSB: Some North American produced RAV4, Highlander, Highlander HV, and Sienna vehicles equipped with manual front seats may exhibit an inoperative forward/rearward adjustment function. Upon closer inspection it may be noticed that the Seat Track Adjusting Handle has become disengaged from the locking levers. APPLICABLE WARRANTY: This repair is covered under the Toyota Basic Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the vehicle's in-service date. Warranty application is limited to occurrence of the specified condition described in this bulletin.
T-TT-0497-18	2018-06-18. Service bulletin. TT: Some vehicles may experience a condition in which the 2nd row seat, with center seat, exhibits a chirp/squeak noise from the rear seat latches (floor area). This condition is present while driving over rough or bumpy roads. Upon further inspection, after removal of the LH 2nd row seat, the rear inboard and outboard strikers may show signs of the coating peeling off as shown in Fig.2 and Fig.3.
T-SB-0152-14	2018-04-23. Service bulletin. TSB: Some 2011 ? 2013 model year Sienna vehicles may exhibit a condition where the outside seat shield is loose and separating, or has an excessive gap to the seat cushion or forward facing seat shield. The condition may occur on either the driver or passenger front power equipped seats. Follow the Repair Procedure in this bulletin to address this condition.
T-SB-0180-12 Rev	2018-04-23. Service bulletin. TSB: OBSOLETE NOTICE December 2, 2015: This bulletin is now obsolete. Please see T-SB-0118-15.
T-SB-0192-11 Rev	2018-04-23. Service bulletin. Some 2011 ? 2014 model year Sienna vehicles with the factory mobility seat option may exhibit a condition where the seat slide function becomes inoperative due to plastic spacer interference in the lift mechanism. The seat lift mechanism has been improved to address this condition.