Service bulletin 83-153
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10052275 |
| Published by NHTSA | 2013-07-08 |
| Manufacturer's number | 83-153 |
| Manufacturer's date | 2013-05-01 |
| NHTSA component | EQUIPMENT:ELECTRICAL |
NHTSA's summary
FREIGHTLINER: PARKSMART WITH DDC OPTIMIZED IDLE. DETROIT DIESEL OPTIMIZED IDLE AFFECTS THE WAY PARKSMART OPERATES. *JS
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Equipment and accessories
| FREIGHTLINER CASCADIA | 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 17V810000 | 2017-12-15. EQUIPMENT |
|---|---|
| 14V588000 | 2014-09-23. EQUIPMENT:ELECTRICAL |
| 12V601000 | 2012-12-21. EQUIPMENT |
| 12V405000 | 2012-08-16. EQUIPMENT |
| 10V551000 | 2010-11-04. EQUIPMENT:OTHER:LABELS |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| TechTalk8048 | 2021-06-02. Service bulletin. Tech Talk continued discussion on Trailer ABS light on even when truck off. |
|---|---|
| FAB144 | 2021-05-18. Service bulletin. Freightliner Action Bulletin FAB144 Smartway Certification |
| TSN 31-06 | 2021-05-13. Service bulletin. TSN for the Thermo King Tripac APU located on the right hand frame rail back of cab / sleeper is installed such that the top of the APU is 76mm (3 inches) above the top flange of the frame rail. Under certain turning conditions and fifth wheel configurations it is possible for the trailer to contact the top cover of the Tripac APU. |
| TSN 01-07c | 2021-05-13. Service bulletin. Beyond routing and wiring concerns, the PCC system as previously implemented suffers from two timing / reporting issues. One stems from the long boot-up time of the PCC module as compared to the CPC (a.k.a. the 6N4C timer issue), and the other stems from the potential of some PCC modules to lock-up (a.k.a. the NAND flash issue). The timer concern is considered to primarily affect EPA10 units (OBD13 already had a longer timer) and most can be resolved by simply refreshing the CPC software (even if an update is not available). The module lock-up software solution is currently being validated, so the PDC stock is not clean yet. However, lock-up is anticipated to only be present in approximately 8% of PCC modules (based on testing), so (ahead of a campaign), here are instructions on how to reactivate a system, verify proper operation, and drive service actions. |
| TechTalk8121 | 2021-05-06. Service bulletin. Tech Talk continuing discussion on ABS 11 SPN 807. |
| WI21-008 | 2021-04-23. Service bulletin. Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021. |
| DT12 Trans Chafe | 2021-04-08. Service bulletin. DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to be causing issues to the After Treatment Control Module (ACM). These fault codes indicated that the ACM communication message was not received by the Motor Control Module (MCM) which in certain cases, led to a 25% engine de-rate situation. Further diagnosis revealed that the DT12 wiring harness was chafing and contacting the transmission TCU case. To reduce potential chafing areas, the proposed short-term containment was to route the wiring harness using additional tie straps. This communication applies to Freightliner and Western Star vehicles built with DT12 transmissions. |
| TechTalk12291K | 2021-04-05. Service bulletin. Tech Talk discussion on not being able to do a forced regen because clutch is depressed. |
| SB83-155 | 2021-03-26. Service bulletin. Updated Freightliner Service Bulletin for Espar Service Information. This bulletin replaces the version dated January 1, 2015. New Cascadia has been added to the model list. |
| TechTalk2414K | 2021-03-05. Service bulletin. Tech Talk discussion on 1845_9 for 1939 TCFG2 message missing ON 2013 CASCADIA. |