# Service bulletin SB\-09\-05\-22\-002 A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned. - Type: Service bulletin - NHTSA id: 10030124 - Published by NHTSA: 2009\-08\-05 - Manufacturer's number: SB\-09\-05\-22\-002 - Manufacturer's date: 2009\-02\-01 - NHTSA component: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP; SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES ## NHTSA's summary CHEVROLET: VEHICLE BRAKE SYSTEM DIAGNOSIS \- INSPECT CLEARANCE OF BRAKE PEDAL ARM TO MAG BEAM \(REPLACE BRAKE PEDAL PUSH ROD\). ON RARE OCCASIONS, THE BRAKES SEEM TO HAVE A SLIGHT APPLY. THE BRAKE PEDAL ARM MAY CAUSE THE BRAKE PEDAL NOT TO RETURN FULLY TO THE REST POSITION. \*PE ## The document No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number. ## Components Brakes, Anti\-lock brakes ## Vehicles listed - 2009 CHEVROLET IMPALA ## Other bulletins for the same vehicles and component - [PIT3271J](/bulletins/10168960.md), 2019-12-09, Service bulletin: WHEELS; SERVICE BRAKES, AIR:ANTILOCK. This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection. - [PIC5468C](/bulletins/10112727.md), 2017-08-15, Service bulletin: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP; SERVICE BRAKES, HYDRAULIC. This Preliminary Information communication provides information to the technician about vehicles with a spongy brake pedal after a hydraulic brake component was disconnected or replaced. The brake lines between the master cylinder and the antilock brake system module are routed higher than the master cylinder. If air enters the system it will travel to this high point if the system is opened for a repair. The technician will need to perform an automated bleed procedure using the scan tool to ensure all the air is purged out of the hydraulic system. - [PIC5992](/bulletins/10111827.md), 2017-08-15, Service bulletin: WHEELS; SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT. This Preliminary Information communication provides the technician with steps to diagnose and repair the vehicle if the ABS lamp is on with Diagnostic Trouble Code C0035 C0040 or unwanted traction control activation. Technician will inspect the Wheel Speed Sensor harness for damage. Technician will repair the broken or damaged wire for the Wheel Speed Sensor. - [PIC\-5992\-A](/bulletins/10078884.md), 2016-08-25, Service bulletin: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT; TRACTION CONTROL SYSTEM; SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT. THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES THE TECHNICIAN WITH STEPS TO DIAGNOSE AND REPAIR THE VEHICLE IF THE ABS LAMP IS ON WITH DIAGNOSTIC TROUBLE CODE C0035 C0040 OR UNWANTED TRACTION CONTROL ACTIVATION. TECHNICIAN WILL INSPECT THE WHEEL SPEED SENSOR HARNESS FOR DAMAGE. TECHNICIAN WILL REPAIR THE BROKEN OR DAMAGED WIRE FOR THE WHEEL SPEED SENSOR. - [PIC\-5992](/bulletins/10055802.md), 2014-07-19, Service bulletin: TRACTION CONTROL SYSTEM; SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT; SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT. CHEVROLET/BUICK/PONTIAC: WHEN TURNING, TRACTION CONTROL SYSTEM \(TCS\) OR ANTI BRAKING SYSTEM LIGHT WILL ILLUMINATE. MODEL 2007\-2015 IMPALA, GRAND PRIX, LACROSSE. \*PE - [PIC\-5268B](/bulletins/10036507.md), 2011-03-25, Service bulletin: SERVICE BRAKES, AIR:ANTILOCK. CHEVROLET: REPEAT BRAKE PULSATION, STEERING WHEEL DITHER, AND/OR PREMATURE BRAKE PAD WEAR. THIS CONDITION AFFECTS VEHICLES DRIVEN PRIMARILY IN MOUNTAINOUS TERRAIN. POLICE VEHICLE WITH RPO 9C1 OR 9C3. \*PE - [08\-05\-25\-004](/bulletins/10026002.md), 2008-09-24, Service bulletin: SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT; SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE; SERVICE BRAKES, AIR:ANTILOCK. GMC: ANTILOCK BRAKE SYSTEM \(ABS\), TRACTION CONTROL SYSTEM \(TCS\) OR STABILITRAK LIGHT ON, DTCS C0035\-C0052 SET \(PERFORM DIAGNOSTIC COMPONENT TEST PROCEDURE AND REPAIR AS NECESSARY\). \*PE UPDATED 5/6/09. \*PE - [PIC\-4868](/bulletins/10025666.md), 2008-08-28, Service bulletin: SERVICE BRAKES, AIR:ANTILOCK; ELECTRONIC STABILITY CONTROL \(ESC\); ELECTRONIC STABILITY CONTROL:AUTOMATIC \(ASC\). ABS, TRACTION CONTROL, OR STABILITY TELL TALES ON \(DTC C0035\-C0052\). THE ABS, TRACTION CONTROL, OR SERVICE STABILITY SYSTEM \(IF EQUIPPED\) WARNING TELLTALES ILLUMINATE. \*PE JSON: [/v1/bulletins/10030124](/v1/bulletins/10030124) [Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%20SB-09-05-22-002&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F10030124&vehicle=Service%20bulletin%20SB-09-05-22-002)