# Service bulletin 06227

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

- Type: Service bulletin
- NHTSA id: 10020676
- Published by NHTSA: 2006\-12\-20
- Manufacturer's number: 06227
- NHTSA component: POWER TRAIN:AUTOMATIC TRANSMISSION

## NHTSA's summary

UN\-COMMANDED TCC APPLY ON THE 1\-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT. \*KB

## The document

No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.

## Components

Transmission and driveline, Automatic transmission

## Vehicles listed

- 2005 to 2006 FORD CROWN VICTORIA
- 2005 to 2006 FORD E\-150
- 2005 to 2006 FORD E\-250
- 2005 to 2006 FORD EXPEDITION
- 2005 to 2006 FORD F\-150

## Other bulletins for the same vehicles and component

- [SSM 51909](/bulletins/10243490.md), 2023-10-04, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION. When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30\-Jun\-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.
- [ASI\-44534](/bulletins/10056196.md), 2014-10-01, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION. FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2\-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003\-2014 F\-SUPER DUTY, E SERIES, EXCURSION, F\-53 MOTORHOME CHASSIS, LOW CAB FORWARD. \*PE
- [ASI\-44404](/bulletins/10055629.md), 2014-06-24, Service bulletin: ENGINE AND ENGINE COOLING:ENGINE:DIESEL; POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER. FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003\-2007 F SUPER DUTY, 2004\-2010 E SERIES, 2003\-2005 EXCURSION.
- [TSB\-09\-19\-12](/bulletins/10032614.md), 2010-04-20, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE \(TCM/PCM/TECM\). FORD: SOME HYBRID VEHICLES MAY EXHIBIT AN INTERMITTENT RED TRIANGLE ON AND STOP SAFELY NOW MESSAGE DISPLAYED ON THE MESSAGE CENTER, ACCOMPANIED BY A SUDDEN RPM LOSS/NO START WITH A DIAGNOSTIC TROUBLE CODE \(DTC\) P1A0C. \*PE
- [CSP\-092408CS\-01](/bulletins/10030866.md), 2009-12-16, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE \(TCM/PCM/TECM\). FORD TRUCK SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN THE CASE OF THE ROUSHCHARGER FOR THE F\-150, THE TRUCKS CALIBRATION ENHANCEMENTS HAS BEEN DEVELOPED TO BETTER ACCOMMODATE REGIONAL VARIATIONS IN PREMIUM FUEL QUALITY. EVEN THOUGH NOT ALL F\-150 ROUSHCHARGED TRUCKS WILL BE AFFECTED BY THESE VARIATIONS. CSC LETTER WAS REC'D. \*PE UPDATED 4/12/10. \*PE
- [TSB\-08\-18\-2](/bulletins/10029205.md), 2009-06-26, Service bulletin: ENGINE AND ENGINE COOLING:ENGINE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE \(TCM/PCM/TECM\). FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. \*PE
- [CSP\-092908CS\-01](/bulletins/10026749.md), 2008-12-12, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE \(TCM/PCM/TECM\); POWER TRAIN:AUTOMATIC TRANSMISSION. ROUSH/FORD: VEHICLES MANUFACTURED BY ROUSH WITH AN INTERCOOLED ROUSH CHARGER HAVE AN OPPORTUNITY FOR AN UPGRADE TO AN ENHANCED PCM CALIBRATION. NOT ALL F150 ROUSHCHARGED VEHICLES WILL BE AFFECTED BY THESE VARIATIONS. \*PE UPDATED 12/16/08. \*PE
- [08\-5\-13](/bulletins/10024828.md), 2008-05-30, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE \(TCM/PCM/TECM\). 4.6L/5.4L\-\-MIL P0506 AND/OR P0505\-\-HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM. \*NJ
- [06391](/bulletins/10021058.md), 2007-02-27, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION. TRANSMISSION OIL COOLER BYPASS VALVE INSPECTION \- PROGRAM EXPIRATION EXTENSION. \*KB
- [061611](/bulletins/10021054.md), 2007-02-27, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION. DTC P0172/P0175 AND/OR DOWNHILL ENGINE SURGE WITH 5.4L ENGINE \- HARSH TRANSMISSION ENGAGEMENT, SHUDDER ON ACCELERATION IN REVERSE AND/OR SHIFT BUSYNESS WITH 5.45L ENGINE AND TORQSHIFT TRANSMISSION. \*KB

JSON: [/v1/bulletins/10020676](/v1/bulletins/10020676)

[Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%2006227&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F10020676&vehicle=Service%20bulletin%2006227)