WenmarOpen by Wenmar Pro

Service bulletin 18115

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10013246
Published by NHTSA2005-04-13
Manufacturer's number18115
Manufacturer's date2004-08-01
NHTSA componentELECTRICAL SYSTEM

NHTSA's summary

VARIOUS DRIVEABILITY CONCERNS SUCH AS HARD START, NO START, HESITATION, RUNS ROUGH, ERRATIC SHIFTS, AND THE MALFUNCTION INDICATOR LAMP ON WITH A VARIETY OF DIAGNOSTIC TROUBLE CODES. WIRING HARNESS CHAFING. *TT

The document

No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.

Components

Electrical system

Vehicles listed
FORD E-1502004, 2005
FORD E-2502004, 2005
FORD E-3502004, 2005
FORD E-4502004, 2005
FORD E-5502004

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
07V5690002007-12-15. ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
05V2700002005-06-10. ELECTRICAL SYSTEM:WIRING
04V4440002004-09-13. ELECTRICAL SYSTEM:WIRING

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
DOR-T7F8K-082020-08-24. Service bulletin. These SKUs are Trailer Brake Control Modules. The customer communication requested return of unsold inventory due to an internal software issue. The internal software issue leads to a false check trailer brake message and Trailer Brake Controller fault whenever the brake pedal is pressed. This will cause the part to be replaced, due to repetitive dashboard warning light, even though it sends signals to the trailer brakes properly.
TSB T2007-022017-03-27. Service bulletin. ON SOME VEHICLES, WHEN THE GATEWAY 401 MODULE TRANSITIONS FROM ITS POWER DOWN MODE (IGNITION OFF) TO ITS POWER UP MODE (IGNITION ON) THE MODULE MAY NOT WAKE UP. IF THIS ACTION OCCURS, THE MODULE'S LED DISPLAY PANELS WILL NOT PROVE-OUT AND THE BACKLIGHTS ON THE LED DISPLAY PANELS WILL NOT ILLUMINATE.
061112006-07-27. Service bulletin. 6.0L - MIL ON WITH DTC P2138, P2139, P2140. *TT
065102006-07-26. Service bulletin. 6.0L - MIL ON WITH DTC P0460. *TT
063102006-05-17. Service bulletin. WATER-IN-FUEL (WIF) LAMP ON. *TT
190822006-04-29. Service bulletin. LACK OF POWER OR MIL ON - TURBOCHARGER STICKING - REVISED DIAGNOSTICS. *TT
190992006-04-28. Service bulletin. P0404 SERVICE TIP. *TT
190192006-02-11. Service bulletin. LOW BATTERY VOLTAGE - 6.0L DIESEL WITH SINGLE ALTERNATOR. *TT
82006-01-14. Service bulletin. FORD-INSTALLED ALTERNATORS. THOMAS BUILT BUSES. *TT
05822005-12-07. Service bulletin. DAYTIME RUNNING LIGHTS INOPERATIVE AND A/C NOT COOLING. *TT